I am helping my neighbor.
He has the 6.2 MX. The boat starts runs great. After about 10 minutes of running wide open the motor has a audible bang and shuts off. The temperature gauge reads 175 degrees. There are no warning beeps. Will not restart until temp goes down to about 160°. Boat fires back up and will idle along no problem. Take it back up to wide open throttle and repeats audible sound (bang) and dies again. Cools down, starts and runs great until 175° again.
I don't believe the problem is mechanical. The motor runs great and has no unusual sounds while running until the "bang" at 175°
Any thoughts?
TIA
2002 6.2 Mercruiser MX
Re: 2002 6.2 Mercruiser MX
Tell your Niehbor that without scanning the event for what fault code is occurring your guessing.
My guess is obviously over heat and limp mode is shutting it completely off ( which is not common)
Or maybe it’s just suffering and needs a rest?!
Take it to a Dealer
My guess is obviously over heat and limp mode is shutting it completely off ( which is not common)
Or maybe it’s just suffering and needs a rest?!
Take it to a Dealer
2008 272 , 496 HO fo SHO
California Delta
Table Rock Lake
#FARCON
California Delta
Table Rock Lake
#FARCON
-
AsLan7
- Fleet Admiral
- Posts: 11526
- Joined: Sat Jul 29, 2017 10:58 am
- Location: Erie PA
- Has thanked: 1 time
- Been thanked: 6 times
- Contact:
Re: 2002 6.2 Mercruiser MX
.
Hey rickk
Welcome to the Cobaltchat forum.
Like Matt mentioned, something is clogging the cooling system and she is going into limp mode to save herself from overheating. A good marine tech can scan this and isolate the problem.
Is this engine in a Cobalt? Any pics?
Again, welcome aboard mate.
.
.
Hey rickk
Welcome to the Cobaltchat forum.
Like Matt mentioned, something is clogging the cooling system and she is going into limp mode to save herself from overheating. A good marine tech can scan this and isolate the problem.
Is this engine in a Cobalt? Any pics?
Again, welcome aboard mate.
.
.
You do not have the required permissions to view the files attached to this post.
2002 Cobalt 262
&
2005 Cobalt 263
496 MagHO
(sold )
Erie, PA
Currently boatless (for now)
will fly for food
(CChat moderator)
&
2005 Cobalt 263
496 MagHO
(sold )
Erie, PA
Currently boatless (for now)
will fly for food
(CChat moderator)
Re: 2002 6.2 Mercruiser MX
Thank you very much fellas for the warm welcome and your ideas. No pictures yet but it is a 26' Cobalt. I agree that she is running hot too. I will have owner take it to marina. Unfortunately, our little lake does not have a reputable dealer.
The impeller had a vein that was split at the core from end to end. I replaced impeller but still is acting the same.
The impeller had a vein that was split at the core from end to end. I replaced impeller but still is acting the same.
Re: 2002 6.2 Mercruiser MX
Did they build a 6.2 in 2002? Maybe it's a Merc thing..
Welcome from Oklahoma, and pics or it never happened!
Welcome from Oklahoma, and pics or it never happened!
2001 262 502 GXI (because it sounds better than an 8.2)
From the Land of the Red Man
"Black Boats Matter"
#FARCON Marine / CC Core!
From the Land of the Red Man
"Black Boats Matter"
#FARCON Marine / CC Core!
-
Big Block Power
- Fleet Admiral
- Posts: 17930
- Joined: Sat May 07, 2016 8:05 pm
- Location: Neenah,Wi
- Contact:
Re: 2002 6.2 Mercruiser MX
Yep. They've been building it for some time.Ytmsn wrote: Tue Jul 02, 2019 6:52 am Did they build a 6.2 in 2002? Maybe it's a Merc thing..
Welcome from Oklahoma, and pics or it never happened!
03Cobalt220 8.1gxi DP
"Kids in Tow2"
"Pot The Jus" Originator :-)
Neenah Wi
#ItsBu'sfault
#FARCON Marine CC Core!
"Kids in Tow2"
"Pot The Jus" Originator :-)
Neenah Wi
#ItsBu'sfault
#FARCON Marine CC Core!
Re: 2002 6.2 Mercruiser MX
My neighbor Terry pulled boat out and took it to a Merc Dealer this morning. I will report back what they find. Thank you again to all who responded
Who is online
Users browsing this forum: No registered users and 19 guests