Page 2 of 3
Re: ‘19 R5 Vibration
Posted: Sun Sep 12, 2021 1:17 pm
by Snowman73
bruceb58 wrote: Sun Sep 12, 2021 12:20 pm
That's is some crazy vibration. Can you make a video with the engine hatch open while someone else drives the boat?
I’ll update later in the week. I sent videos and dropped boat at dealer. I figure if it’s there they are more apt to look at it and figure it out. I appreciate all the help so far. I did find this nick in the prop but doesn’t explain why it’s getting worse and hard yo believe it could cause that much vibration.
Re: ‘19 R5 Vibration
Posted: Sun Sep 12, 2021 2:12 pm
by Snowman8
I wouldn’t think a nick that small would even be noticeable. I bet I have a few just like that in my props. I had one bigger than that a couple years from a single hit that luckily only hit one blade. I can’t feel any vibration in my props at all. The one bigger hit that I had left a sharp edge that I just lightly filed smooth and I don’t notice anything as far as vibration. Every winter I say that I am going to pull them and send them in to be balanced but I never get around to it.
Re: ‘19 R5 Vibration
Posted: Sun Sep 12, 2021 5:17 pm
by Snowman73
Snowman8 wrote: Sun Sep 12, 2021 2:12 pm
I wouldn’t think a nick that small would even be noticeable. I bet I have a few just like that in my props. I had one bigger than that a couple years from a single hit that luckily only hit one blade. I can’t feel any vibration in my props at all. The one bigger hit that I had left a sharp edge that I just lightly filed smooth and I don’t notice anything as far as vibration. Every winter I say that I am going to pull them and send them in to be balanced but I never get around to it.
. Me either.
Re: ‘19 R5 Vibration
Posted: Sun Sep 12, 2021 10:28 pm
by bruceb58
There is no way that nick is doing it. I hit a rock one year on my rear prop and bent the blade. I was able to hammer it back a little bit and used the boat that way for a few days and it didn't have the vibration you have.
Re: ‘19 R5 Vibration
Posted: Mon Sep 13, 2021 8:10 am
by dustinm
I bet one of your ujoints are "dry" and causing a binding situation. When the tech checked the ujoints he was just checking for looseness which it probably hasnt advanced that far yet.
Re: ‘19 R5 Vibration
Posted: Wed Sep 15, 2021 6:56 pm
by Snowman73
Update: props are being sent out for balance. Dealer didn’t have a new set of FH5 or 6 in stock. No new ones available due to covid (imagine that). Dealer pulled rear unit and rechecked bearings and u-joints and confirmed again no issue. Props should be back Saturday.
Re: ‘19 R5 Vibration
Posted: Thu Sep 16, 2021 6:19 pm
by Big Block Power
Snowman73 wrote: Wed Sep 15, 2021 6:56 pm
Update: props are being sent out for balance. Dealer didn’t have a new set of FH5 or 6 in stock. No new ones available due to covid (imagine that). Dealer pulled rear unit and rechecked bearings and u-joints and confirmed again no issue. Props should be back Saturday.
Cross our fingers. They don't have any boats either? Lol
Is it Gordys?
Re: ‘19 R5 Vibration
Posted: Sun Sep 26, 2021 12:44 pm
by Snowman73
Well just wanted to close the loop on this subject in case others have something similar one day. Finally got out on the water today for about twenty minutes. Seems like the prop balancing fixed the issue. Boat season is over for me this year. Dropped it off for winterizing this afternoon.
Re: ‘19 R5 Vibration
Posted: Sun Sep 26, 2021 2:43 pm
by Big Block Power
Snowman73 wrote: Sun Sep 26, 2021 12:44 pm
Well just wanted to close the loop on this subject in case others have something similar one day. Finally got out on the water today for about twenty minutes. Seems like the prop balancing fixed the issue. Boat season is over for me this year. Dropped it off for winterizing this afternoon.
Good deal. Now quit hitting stuff! Or things hiting you
Is that the new swim platform?
Re: ‘19 R5 Vibration
Posted: Sun Sep 26, 2021 4:27 pm
by Snowman73
Big Block Power wrote: Sun Sep 26, 2021 2:43 pm
Snowman73 wrote: Sun Sep 26, 2021 12:44 pm
Well just wanted to close the loop on this subject in case others have something similar one day. Finally got out on the water today for about twenty minutes. Seems like the prop balancing fixed the issue. Boat season is over for me this year. Dropped it off for winterizing this afternoon.
Good deal. Now quit hitting stuff! Or things hiting you
Is that the new swim platform?
I’m blaming it on my daughter. She drives the boat now.
Re: ‘19 R5 Vibration
Posted: Sun Sep 26, 2021 5:27 pm
by Snowman8
Snowman73 wrote: Sun Sep 26, 2021 12:44 pm
Well just wanted to close the loop on this subject in case others have something similar one day. Finally got out on the water today for about twenty minutes. Seems like the prop balancing fixed the issue. Boat season is over for me this year. Dropped it off for winterizing this afternoon.
Wow, I never would have guessed that. I have a few small nicks in both of my props but I don’t have any vibration. After 6 years I was kinda thinking about pulling them this winter and sending them to a prop shop to have them balanced and checked out. Now I’m thinking harder about it. Does anyone know of a good place to send Volvo props for balancing?
Re: ‘19 R5 Vibration
Posted: Sun Sep 26, 2021 5:56 pm
by Big Block Power
Snowman8 wrote: Sun Sep 26, 2021 5:27 pm
Snowman73 wrote: Sun Sep 26, 2021 12:44 pm
Well just wanted to close the loop on this subject in case others have something similar one day. Finally got out on the water today for about twenty minutes. Seems like the prop balancing fixed the issue. Boat season is over for me this year. Dropped it off for winterizing this afternoon.
Wow, I never would have guessed that. I have a few small nicks in both of my props but I don’t have any vibration. After 6 years I was kinda thinking about pulling them this winter and sending them to a prop shop to have them balanced and checked out. Now I’m thinking harder about it. Does anyone know of a good place to send Volvo props for balancing?
The prop of course doesn't have to show damage to be out of balance. I got my crappy Hill Marine props brand new and every blade was a different shape and thickness.
So I would send them to Bblades here in Wisconsin.
He blueprinted and balanced mine and redid the blades completely to make them his own. Off season you save 10%
https://bblades.com
Re: ‘19 R5 Vibration
Posted: Sun Sep 26, 2021 6:23 pm
by Snowman73
I’m wondering if a motor mount settled or something causing the out of balance to be noticeable? Unless I did “hit” something??
Re: ‘19 R5 Vibration
Posted: Sun Sep 26, 2021 7:14 pm
by Snowman8
Big Block Power wrote: Sun Sep 26, 2021 5:56 pm
Snowman8 wrote: Sun Sep 26, 2021 5:27 pm
Snowman73 wrote: Sun Sep 26, 2021 12:44 pm
Well just wanted to close the loop on this subject in case others have something similar one day. Finally got out on the water today for about twenty minutes. Seems like the prop balancing fixed the issue. Boat season is over for me this year. Dropped it off for winterizing this afternoon.
Wow, I never would have guessed that. I have a few small nicks in both of my props but I don’t have any vibration. After 6 years I was kinda thinking about pulling them this winter and sending them to a prop shop to have them balanced and checked out. Now I’m thinking harder about it. Does anyone know of a good place to send Volvo props for balancing?
The prop of course doesn't have to show damage to be out of balance. I got my crappy Hill Marine props brand new and every blade was a different shape and thickness.
So I would send them to Bblades here in Wisconsin.
He blueprinted and balanced mine and redid the blades completely to make them his own. Off season you save 10%
https://bblades.com
Thanks BB. Do you mind me asking what they charged you to balance and rebuild your props?
Re: ‘19 R5 Vibration
Posted: Sun Sep 26, 2021 8:12 pm
by Big Block Power
Snowman8 wrote: Sun Sep 26, 2021 7:14 pm
Big Block Power wrote: Sun Sep 26, 2021 5:56 pm
Snowman8 wrote: Sun Sep 26, 2021 5:27 pm
Wow, I never would have guessed that. I have a few small nicks in both of my props but I don’t have any vibration. After 6 years I was kinda thinking about pulling them this winter and sending them to a prop shop to have them balanced and checked out. Now I’m thinking harder about it. Does anyone know of a good place to send Volvo props for balancing?
The prop of course doesn't have to show damage to be out of balance. I got my crappy Hill Marine props brand new and every blade was a different shape and thickness.
So I would send them to Bblades here in Wisconsin.
He blueprinted and balanced mine and redid the blades completely to make them his own. Off season you save 10%
https://bblades.com
Thanks BB. Do you mind me asking what they charged you to balance and rebuild your props?
$800 I think. 4 blades each. But they are purdy
. Me either.